NM090BY02S12V螺桿泵NM076SF03S18B定子NM090-01L

天津單螺桿泵定子EH ER EP MEH EL ES EU

EH236-V-W201

EH1024-V-W201

 由于材質工藝等區別價格影響較大,以咨詢客服 實際成交價為準.

南京科友工業設備有限公司

18O.18O.723.97 李常志

EH1500-V-W201

發展史

 螺桿泵，發明了這種單螺桿泵，世人稱之為泵。1951年家族的艾尼爾.先生在建廠并開始大規模生產泵，其一的品質和服務受到廣大用戶的稱贊，并被專稱為奈莫泵。  

1.奈莫泵是一種容積式泵，泵被廣泛用于各行業輸送各類介質，恒壓連續運行，無脈動，介質輸送無破損，通過調節轉速改變量達到計量的目的。 

2.固體含量高（大粒徑可達150mm）；各種粘度（1mPas-3*106mPas）的介質；觸變性和易膨脹性介質；剪切敏感性介質；磨蝕性介質；有/無自潤滑性的介質； 磨蝕性介質(PH=0~14)； 粘結性介質；有毒性介質；量范圍大、壓力等級高；量范圍從每小時幾毫升到500立方米； 壓力范圍達48BAR,特殊設計可達72BAR.。  

3.高吸上高度可達9m水柱，可雙向旋轉，雙向輸送，安裝方式靈活，運行順暢、平穩、噪音低、無脈沖、無剪切，輸送介質溫度范圍:-20 到300攝氏度。

 螺桿泵的使用和維護

  1。泵首次使用時必須向泵內注入清水或被輸送的液體，并用輔助工具“盤動”靈活后，再通電啟動，以免“干運轉”和“粘結”損壞定子。
  2。泵啟動前必須全部打開進出口管路中的閥門，停泵后才能全部關閉進出口管路中的閥門。
  3。泵的轉向必須與泵上的標記一致，如確需反轉時，則必須將泵的進出口對調。
  4。量調節只能調節回管上的回閥開啟度或螺桿轉速，不能依靠調節泵出口閥的關閉程度來調節量。
  5。運行中若發現吸力，出口壓力和量下降時，說明定子已經磨損，適當調節定子外的螺釘，收緊定子形腔，泵即可正常運行。調節時，以手感覺定子—螺桿齒合的松緊程度與新泵時相似為宜。
  6。經常檢查各處螺栓的松緊程度，軸承溫升，是否缺油，密封狀況，發現問題即時處理。
  7。在輸送高粘度，含固體顆?；蚋g性的介質后，必須即時將泵腔清洗干凈，防止沉淀或腐蝕。
  8。泵在高寒地區冬季使用后，必須即時清洗干凈，打開三通下面的蘿塞，放凈積液，以防凍壞。若下次使用的間斷時間較長，必須間接加熱融化泵內殘留介質，(但不允許向泵腔內通入蒸氣)。并用輔助工具轉幾轉以后，才能通電啟動。
  9。新泵運行300小時后，軸承換新油，以后每運行1500小時后，換一次油。新減速器運行7—14天后換新油，以后每運行3—6個月后換一次油。
  10。運行中若發生異常情況，立即停車，查明原因，排除故障。

 ® M.Champ®泵的優點

                                  ·結構緊湊，維護方便,運行成本低
  ·泵的量與轉速成正比
  ·可以正反雙向輸送
  ·自吸性能好，排出能力強
  ·輸送過程連續，脈動低，適用于各種壓力和粘性的工礦和介質
  ·定子帶有喇叭型入口，可以保證較低的NPSH值
  ·機械密封處于介質中，可及時被介質沖洗
  ·在泵中配有一個與原定子一體的備用定子，經簡單掉頭安裝就能投入使用
  ·撓性連軸桿無磨損免維修
  ·快速夾裝定子系統，松開排出體上的連接螺栓，就可以拆卸蓋板和更換定而不需要移動泵的任何其它
   部件，泵的蓋板同時也是該泵的信息銘牌，上面帶有詳細的操作說明和維護說明等資料
  ·標準的軸插入式減速電機，結構緊湊，堅固耐用，減速電機通過空心軸與泵直接相連。簡單的鎖緊裝
   置使得轉動部件的維修非常簡單

本公司大量供應NM015/021/031/038/045/053/063/076/090/105BY(SY)/01L06B系列螺桿泵

 C系列泵是一種結構緊湊，性能優異，具有價格優勢的單螺桿泵，泵體材料為鑄鐵或者不銹鋼，根據客戶要求，各種定轉子材料包括硬鉻鍍層轉子可供選擇。長距離或者高揚程輸送工況下，可以通過減小管路管徑或者減少泵的數量等，降低了投資成本。泵的運行轉速降低，減少了設備的磨損和日常維護，從而延長了泵的使用時間并增加了經濟性。

泵主要應用于生活和工業廢水、石灰漿料、污泥、對剪切刀敏感的乳膠、牛奶，調味品，果汁、化工原料和清潔劑、淀粉漿料、涂料，石膏和硅酸鹽、造紙、農業泥漿等。

本公司大量供應C1BK/C1AK/C19K/C18K/S18K/C17K/S17K/C16K/S16K/C15K/S15K/C14K/S14K/C1XK/C23K/C1BA/

C1BB/C1AA/C1AB/C19A/C19B/C18A/S18A/C18B/C2XA/C23A/C22A

NM011BY01S06B、NM011BY02S12B、NM011BY03S18B、NM011BY04S18B

NM015BY01S06B、NM015BY02S12B、NM015BY03S18B、NM015BY04S18B

NM021BY01S06B、NM021BY02S12B、NM021BY03S18B、NM021BY04S18B

NM031BY01S06B、NM031BY02S12B、NM031BY03S18B、NM031BY04S18B

NM038BY01S06B、NM038BY02S12B、NM038BY03S18B、NM038BY04S18B

NM045BY01S06B、NM045BY02S12B、NM045BY03S18B、NM045BY04S18B

NM053BY01S06B、NM053BY02S12B、NM053BY03S18B、NM053BY04S18B

NM063BY01S06B、NM063BY02S12B、NM063BY03S18B、NM063BY04S18B

NM076BY01S06B、NM076BY02S12B、NM076BY03S18B、NM076BY04S18B

NM090BY01S06B、NM090BY02S12B、NM090BY03S18B、NM090BY04S18B

NM105BY01S06B、NM105BY02S12B、NM105BY03S18B、NM105BY04S18B

NM125BY01S06B、NM125BY02S12B、NM125BY03S18B、NM125BY04S18B

NM145BY01S06B、NM145BY02S12B、NM145BY03S18B、NM145BY04S18B

NM148BY01S06B、NM148BY02S12B、NM148BY03S18B、NM148BY04S18B

NM011BY01L06B、NM011BY02L12B、NM011BY03L18B、NM011BY04L18B

NM015BY01L06B、NM015BY02L12B、NM015BY03L18B、NM015BY04L18B

NM021BY01L06B、NM021BY02L12B、NM021BY03L18B、NM021BY04L18B

NM031BY01L06B、NM031BY02L12B、NM031BY03L18B、NM031BY04L18B

NM038BY01L06B、NM038BY02L12B、NM038BY03L18B、NM038BY04L18B

NM045BY01L06B、NM045BY02L12B、NM045BY03L18B、NM045BY04L18B

NM053BY01L06B、NM053BY02L12B、NM053BY03L18B、NM053BY04L18B

NM063BY01L06B、NM063BY02L12B、NM063BY03L18B、NM063BY04L18B

NM076BY01L06B、NM076BY02L12B、NM076BY03L18B、NM076BY04L18B

NM090BY01L06B、NM090BY02L12B、NM090BY03L18B、NM090BY04L18B

NM105BY01L06B、NM105BY02L12B、NM105BY03L18B、NM105BY04L18B

NM125BY01L06B、NM125BY02L12B、NM125BY03L18B、NM125BY04L18B

NM145BY01L06B、NM145BY02L12B、NM145BY03L18B、NM145BY04L18B

NM148BY01L06B、NM148BY02L12B、NM148BY03L18B、NM148BY04L18B

NM011SY01S06B、NM011SY02S12B、NM011SY03S18B、NM011SY04S18B

NM015SY01S06B、NM015SY02S12B、NM015SY03S18B、NM015SY04S18B

NM021SY01S06B、NM021SY02S12B、NM021SY03S18B、NM021SY04S18B

NM031SY01S06B、NM031SY02S12B、NM031SY03S18B、NM031SY04S18B

NM038SY01S06B、NM038SY02S12B、NM038SY03S18B、NM038SY04S18B

NM045SY01S06B、NM045SY02S12B、NM045SY03S18B、NM045SY04S18B

NM053SY01S06B、NM053SY02S12B、NM053SY03S18B、NM053SY04S18B

NM063SY01S06B、NM063SY02S12B、NM063SY03S18B、NM063SY04S18B

NM076SY01S06B、NM076SY02S12B、NM076SY03S18B、NM076SY04S18B

NM090SY01S06B、NM090SY02S12B、NM090SY03S18B、NM090SY04S18B

NM105SY01S06B、NM105SY02S12B、NM105SY03S18B、NM105SY04S18B

NM125SY01S06B、NM125SY02S12B、NM125SY03S18B、NM125SY04S18B

NM145SY01S06B、NM145SY02S12B、NM145SY03S18B、NM145SY04S18B

NM148SY01S06B、NM148SY02S12B、NM148SY03S18B、NM148SY04S18B

NM011SY01S06V、NM011SY02S12V、NM011SY03S18V、NM011SY04S18V

NM015SY01S06V、NM015SY02S12V、NM015SY03S18V、NM015SY04S18V

NM021SY01S06V、NM021SY02S12V、NM021SY03S18V、NM021SY04S18V

NM031SY01S06V、NM031SY02S12V、NM031SY03S18V、NM031SY04S18V

NM038SY01S06V、NM038SY02S12V、NM038SY03S18V、NM038SY04S18V

NM045SY01S06V、NM045SY02S12V、NM045SY03S18V、NM045SY04S18V

NM053SY01S06V、NM053SY02S12V、NM053SY03S18V、NM053SY04S18V

NM063SY01S06V、NM063SY02S12V、NM063SY03S18V、NM063SY04S18V

NM076SY01S06V、NM076SY02S12V、NM076SY03S18V、NM076SY04S18V

NM090SY01S06V、NM090SY02S12V、NM090SY03S18V、NM090SY04S18V

NM105SY01S06V、NM105SY02S12V、NM105SY03S18V、NM105SY04S18V

NM125SY01S06V、NM125SY02S12V、NM125SY03S18V、NM125SY04S18V

NM145SY01S06V、NM145SY02S12V、NM145SY03S18V、NM145SY04S18V

NM148SY01S06V、NM148SY02S12V、NM148SY03S18V、NM148SY04S18V

NM011BY01S06V、NM011BY02S12V、NM011BY03S18V、NM011BY04S18V

NM015BY01S06V、NM015BY02S12V、NM015BY03S18V、NM015BY04S18V

NM021BY01S06V、NM021BY02S12V、NM021BY03S18V、NM021BY04S18V

NM031BY01S06V、NM031BY02S12V、NM031BY03S18V、NM031BY04S18V

NM038BY01S06V、NM038BY02S12V、NM038BY03S18V、NM038BY04S18V

NM045BY01S06V、NM045BY02S12V、NM045BY03S18V、NM045BY04S18V

NM053BY01S06V、NM053BY02S12V、NM053BY03S18V、NM053BY04S18V

NM063BY01S06V、NM063BY02S12V、NM063BY03S18V、NM063BY04S18V

NM076BY01S06V、NM076BY02S12V、NM076BY03S18V、NM076BY04S18V

NM090BY01S06V、NM090BY02S12V、NM090BY03S18V、NM090BY04S18V

NM105BY01S06V、NM105BY02S12V、NM105BY03S18V、NM105BY04S18V

NM125BY01S06V、NM125BY02S12V、NM125BY03S18V、NM125BY04S18V

NM145BY01S06V、NM145BY02S12V、NM145BY03S18V、NM145BY04S18V

NM148BY01S06V、NM148BY02S12V、NM148BY03S18V、NM148BY04S18V

NM011BY01P06V、NM011BY02P12V、NM011BY03P18V、NM011BY04P18V

NM015BY01P06V、NM015BY02P12V、NM015BY03P18V、NM015BY04P18V

NM021BY01P06V、NM021BY02P12V、NM021BY03P18V、NM021BY04P18V

NM031BY01P06V、NM031BY02P12V、NM031BY03P18V、NM031BY04P18V

NM038BY01P06V、NM038BY02P12V、NM038BY03P18V、NM038BY04P18V

NM045BY01P06V、NM045BY02P12V、NM045BY03P18V、NM045BY04P18V

NM053BY01P06V、NM053BY02P12V、NM053BY03P18V、NM053BY04P18V

NM063BY01P06V、NM063BY02P12V、NM063BY03P18V、NM063BY04P18V

NM076BY01P06V、NM076BY02P12V、NM076BY03P18V、NM076BY04P18V

NM090BY01P06V、NM090BY02P12V、NM090BY03P18V、NM090BY04P18V

NM105BY01P06V、NM105BY02P12V、NM105BY03P18V、NM105BY04P18V

NM125BY01P06V、NM125BY02P12V、NM125BY03P18V、NM125BY04P18V

NM145BY01P06V、NM145BY02P12V、NM145BY03P18V、NM145BY04P18V

NM148BY01P06V、NM148BY02P12V、NM148BY03P18V、NM148BY04P18V

NM011BY01P06B、NM011BY02P12B、NM011BY03P18B、NM011BY04P18B

NM015BY01P06B、NM015BY02P12B、NM015BY03P18B、NM015BY04P18B

NM021BY01P06B、NM021BY02P12B、NM021BY03P18B、NM021BY04P18B

NM031BY01P06B、NM031BY02P12B、NM031BY03P18B、NM031BY04P18B

NM038BY01P06B、NM038BY02P12B、NM038BY03P18B、NM038BY04P18B

NM045BY01P06B、NM045BY02P12B、NM045BY03P18B、NM045BY04P18B

NM053BY01P06B、NM053BY02P12B、NM053BY03P18B、NM053BY04P18B

NM063BY01P06B、NM063BY02P12B、NM063BY03P18B、NM063BY04P18B

NM076BY01P06B、NM076BY02P12B、NM076BY03P18B、NM076BY04P18B

NM090BY01P06B、NM090BY02P12B、NM090BY03P18B、NM090BY04P18B

NM105BY01P06B、NM105BY02P12B、NM105BY03P18B、NM105BY04P18B

NM125BY01P06B、NM125BY02P12B、NM125BY03P18B、NM125BY04P18B

NM145BY01P06B、NM145BY02P12B、NM145BY03P18B、NM145BY04P18B

NM148BY01P06B、NM148BY02P12B、NM148BY03P18B、NM148BY04P18B

  NM011BY01L06B、NM011SY02S12B、NM021SY03S18B、NM021SY04S24B

  NM021BY01L06B、NM021SY02S12B、NM021SY03S18B、NM021SY04S24B

  NM021BY01L06B、NM021SY02S12B、NM021SY03S18B、NM021SY04S24B

  NM031BY01L06B、NM031SY02S12B、NM031SY03S18B、NM031SY04S24B

  NM038BY01L06B、NM038SY02S12B、NM038SY03S18B、NM045BY01L06B

  NM045SY02S12B、NM045SY03S18B、NM045SY04S24B、NM053BY01L06B

  NM053SY02S12B、NM053SY03S18B、NM053SY03S18V、NM063BY01L06B

  NM063SY02S12B、NM063SY03S18B、NM063SY03S18B、NM063SY03S18B

  NM063SY04S24B、NM063SY04S24B、NM076BY01L06B、NM076SY02S12B

  NM076SY03S18B、NM076SY03S18B、NM076SY03S18B、NM076SY04S24B

  NM076SY04S24B、NM090BY01L06B、NM090SY02S12B、NM090SY03S18B

  NM090SY03S18B、NM090SY03S18B、NM090SY04S24B、NM090SY04S24B

  NM090SY08S48B、NM105BY01L06B、NM105SY02S12B、NM105SY03S18B

  NM105SY03S18B、NM105SY03S18B、NM105SY04S24B、NM105SY04S24B

  NM125BY01L06B、NM125SY02S12B、NM125SY03S18B、NM125SY03S18B

  NM125SY03S18B、NM125SY04S24B、NM125SY04S24B、NM145BY01L06B

  NM145SY02S12B、NM145SY03S18B、NM148BY01L06B、NM148SY02S12B

  NM148SY03S18B

NM011BF01S06B、NM011BF02S12B、NM011BF03S18B、NM011BF04S18B

NM015BF01S06B、NM015BF02S12B、NM015BF03S18B、NM015BF04S18B

NM021BF01S06B、NM021BF02S12B、NM021BF03S18B、NM021BF04S18B

NM031BF01S06B、NM031BF02S12B、NM031BF03S18B、NM031BF04S18B

NM038BF01S06B、NM038BF02S12B、NM038BF03S18B、NM038BF04S18B

NM045BF01S06B、NM045BF02S12B、NM045BF03S18B、NM045BF04S18B

NM053BF01S06B、NM053BF02S12B、NM053BF03S18B、NM053BF04S18B

NM063BF01S06B、NM063BF02S12B、NM063BF03S18B、NM063BF04S18B

NM076BF01S06B、NM076BF02S12B、NM076BF03S18B、NM076BF04S18B

NM090BF01S06B、NM090BF02S12B、NM090BF03S18B、NM090BF04S18B

NM105BF01S06B、NM105BF02S12B、NM105BF03S18B、NM105BF04S18B

NM125BF01S06B、NM125BF02S12B、NM125BF03S18B、NM125BF04S18B

NM145BF01S06B、NM145BF02S12B、NM145BF03S18B、NM145BF04S18B

NM148BF01S06B、NM148BF02S12B、NM148BF03S18B、NM148BF04S18B

NM011SF01S06B、NM011SF02S12B、NM011SF03S18B、NM011SF04S18B

NM015SF01S06B、NM015SF02S12B、NM015SF03S18B、NM015SF04S18B

NM021SF01S06B、NM021SF02S12B、NM021SF03S18B、NM021SF04S18B

NM031SF01S06B、NM031SF02S12B、NM031SF03S18B、NM031SF04S18B

NM038SF01S06B、NM038SF02S12B、NM038SF03S18B、NM038SF04S18B

NM045SF01S06B、NM045SF02S12B、NM045SF03S18B、NM045SF04S18B

NM053SF01S06B、NM053SF02S12B、NM053SF03S18B、NM053SF04S18B

NM063SF01S06B、NM063SF02S12B、NM063SF03S18B、NM063SF04S18B

NM076SF01S06B、NM076SF02S12B、NM076SF03S18B、NM076SF04S18B

NM090SF01S06B、NM090SF02S12B、NM090SF03S18B、NM090SF04S18B

NM105SF01S06B、NM105SF02S12B、NM105SF03S18B、NM105SF04S18B

NM125SF01S06B、NM125SF02S12B、NM125SF03S18B、NM125SF04S18B

NM145SF01S06B、NM145SF02S12B、NM145SF03S18B、NM145SF04S18B

NM148SF01S06B、NM148SF02S12B、NM148SF03S18B、NM148SF04S18B

NM011BF01L06B、NM011BF02L12B、NM011BF03L18B、NM011BF04L18B

NM015BF01L06B、NM015BF02L12B、NM015BF03L18B、NM015BF04L18B

NM021BF01L06B、NM021BF02L12B、NM021BF03L18B、NM021BF04L18B

NM031BF01L06B、NM031BF02L12B、NM031BF03L18B、NM031BF04L18B

NM038BF01L06B、NM038BF02L12B、NM038BF03L18B、NM038BF04L18B

NM045BF01L06B、NM045BF02L12B、NM045BF03L18B、NM045BF04L18B

NM053BF01L06B、NM053BF02L12B、NM053BF03L18B、NM053BF04L18B

NM063BF01L06B、NM063BF02L12B、NM063BF03L18B、NM063BF04L18B

NM076BF01L06B、NM076BF02L12B、NM076BF03L18B、NM076BF04L18B

NM090BF01L06B、NM090BF02L12B、NM090BF03L18B、NM090BF04L18B

NM105BF01L06B、NM105BF02L12B、NM105BF03L18B、NM105BF04L18B

NM125BF01L06B、NM125BF02L12B、NM125BF03L18B、NM125BF04L18B

NM145BF01L06B、NM145BF02L12B、NM145BF03L18B、NM145BF04L18B

NM148BF01L06B、NM148BF02L12B、NM148BF03L18B、NM148BF04L18B

NM011SF01L06B、NM011SF02L12B、NM011SF03L18B、NM011SF04L18B

NM015SF01L06B、NM015SF02L12B、NM015SF03L18B、NM015SF04L18B

NM021SF01L06B、NM021SF02L12B、NM021SF03L18B、NM021SF04L18B

NM031SF01L06B、NM031SF02L12B、NM031SF03L18B、NM031SF04L18B

NM038SF01L06B、NM038SF02L12B、NM038SF03L18B、NM038SF04L18B

NM045SF01L06B、NM045SF02L12B、NM045SF03L18B、NM045SF04L18B

NM053SF01L06B、NM053SF02L12B、NM053SF03L18B、NM053SF04L18B

NM063SF01L06B、NM063SF02L12B、NM063SF03L18B、NM063SF04L18B

NM076SF01L06B、NM076SF02L12B、NM076SF03L18B、NM076SF04L18B

NM090SF01L06B、NM090SF02L12B、NM090SF03L18B、NM090SF04L18B

NM105SF01L06B、NM105SF02L12B、NM105SF03L18B、NM105SF04L18B

NM125SF01L06B、NM125SF02L12B、NM125SF03L18B、NM125SF04L18B

NM145SF01L06B、NM145SF02L12B、NM145SF03L18B、NM145SF04L18B

NM148SF01L06B、NM148SF02L12B、NM148SF03L18B、NM148SF04L18B

EH1500-P-W201

EH1500-J-W201

EH2650-V-W201

 EH4500-V-W201

EH6300-V-W201

2、系列

H系列為基本系列，臥式泵

3、軸封

特點：
  EH系列為臥式安裝，法蘭連接
  型線設計特點為大偏心，大導程，提高襯套壽命，密封線長，減少泄漏。
  不同級數的襯套長度是不變的，只改變導程，不同級數泵的安裝尺寸不變。
性能范圍：
  壓力：
  單級0.6MPa ; 雙級 1.2 MPa；三級1.8 MPa；四級2.4 MPa
  流量：300m3/h
  粘度：2.7*105cSt
  允許溫度：150℃.
應用范圍：廣泛應用于石油、化工、造船、食品、紡織等各種工業中。●EH單螺桿泵(污泥螺桿泵)特點：     機械振動小、無脈動、運轉平穩。 高的吸入性能。 可輸送含有纖維物和固體顆粒的液體，非常粘稠的含水或含有氣體的所有介質。 ●EH單螺桿泵(污泥螺桿泵)性能范圍： 壓力范圍： 0-1.2Mpa 流量范圍： 290m /h 允許高溫度 200 ℃ 大粘度：2700000cst●EH單螺桿泵(污泥螺桿泵)應用范圍： 該螺桿泵可用于輸送中性或腐蝕性的液體，潔凈的或磨損性的液體，含有氣體或易產生氣泡的液體，高粘度或低粘度液體，包括含有纖維物和固體物質的液體。 食品業：用于酒廠輸送酒、廢渣及制酒流程中的投配料的輸送。 紡織業：用于輸送合成纖維液、粘膠液、染料、油墨、尼龍粉液。 造紙業：用于紙漿黑液的輸送。 石油業：用于多種油類 ; 油脂產品的地面集輸泵。 化工業：用于輸送各種懸浮液、乳膠液、酸、堿、鹽等。 造船業：用于輸送渣油、掃艙和污水、海水等。 建筑業：輸送灰漿、灰膏。 核工業：輸送帶顆粒的放射性液體。 冶金與礦山業：用于輸送氧化物和廢水、礦井排水和的輸送。 選泵注意事項:根據介質的磨損性選擇泵的轉速:表中給出了所輸送的具體介質及其磨損性的特例,請注意介質的特性隨起濃度和溫度的變化而變化,當泵的規格越大時,轉速應選低一些.

按介質粘度選擇泵的轉速

按輸出壓力定級數

   注:在選擇轉速時也要根據經驗.因為一些其他因素也影響著轉速的選擇,在后確定了上述數值的同時,與協商而定.

SYDEX螺桿泵SYDEX定子SYDEX轉子 西德士

意大利SYDEX致力于制造優良、的SYDEX螺桿泵，在提高產品的同時，盡可能的為客戶節省成本。SYDEX螺桿泵保證可靠、節省空間、快捷和安全。Sydex將單螺桿泵可以提供各種型式和各種應用的泵，產品覆蓋面廣，從而得到世界各地用戶的好評。SYDEX螺桿泵應用于造紙，制藥，化學，混合物等領域。SYDEX螺桿泵成本低，通用性強，輸送，流量平穩無脈動，低氣蝕余量有多種形式選擇。BK 032-1L BK 039-1L、LK 065-1L、BG 052-2S、LG 052-2S、WL65-1S、WL75-1S、WL91-1S、WL102-1S、FMS 60/4

SYDEX制造各種高質量，高的螺桿泵和粉碎機，這些螺桿泵是粉碎機，也稱為螺旋轉子泵，廢水泵，有時也稱為螺桿泵或簡稱PC泵。

SYDEX螺桿泵采用原始的Moineau?泵設計，定子固定在鋼管中（流量從6 L / h到240 m3 / h，壓力到48 bar）。 我們的廢水泵和浸漬泵安裝在世界各地。

SYDEX定子制造能力使我們能夠確保的質量，同時提供具有成本效益的解決方案和可靠的交貨時間。

衛生級腔泵-H系列

SYDEX衛生級螺桿泵系列經過設計以滿足嚴格的食品和衛生要求，可避免產品在生產過程中受到污染和變質。這種衛生的PCP非常尊重泵送產品，該產品始終輕柔地輸送。螺桿泵的工作原理本質上是“低剪切”，并且泵送流體不會突然變化，否則會損壞產品。 H系列制造時沒有任何停滯區域，可提供就地清潔系統（CIP）和旁路端口。

這種食品級螺桿泵適用于多種食品和飲料應用。對于濃縮的高粘度液體，該泵可以低速運行，并且可以制造成具有擴大的進口或帶有螺旋鉆和料斗，以將物料輸送到泵中。

食品級油潤滑接頭，高粘度螺旋進料，多級高壓，衛生應用和敏感食品的理想選擇，設計用于清除“死區”的密封外殼，FDA認證的彈性體定子，包括白色腈（可選配不銹鋼蓋）